一般情況下水泥自動攪拌車車開3年基本各種問題就出現了，我開了7年的攪拌車，只維修過兩次，一次是水泵，一次是水泥凝固在了攪拌罐子里，都不是什么大毛病，看看我是怎么在日常進行維護它的。

了解它要先知道它的構成部分，主要和次要，然后在進行維護你的攪拌車基本不會壞。

目前，全車生產廠家全自動化無縫焊接，環縫、縱縫均為全自動無縫焊接。
I’ve been driving a mixer for seven years and only had it repaired twice, once for a pump and once for water to set in a mixing tank. It’s not a big deal, see How I maintain it on a daily basis. Understand it to know its components, primary and secondary, and then carry out maintenance your mixer basic will not be damaged. At present, the car manufacturers fully automated seamless welding, girth, Longitudinal seam are fully automatic seamless welding.

小方量攪拌車液壓泵是選用量泵好還是變量泵好？

水力泵站是三方混凝土攪拌車的主要部件，一般低于6臺攪拌車都是標配的定量泵，不過建議選用變量泵，選好了之后要每天清洗，如果沒時間可以一周清潔一次，這個看個人。
Small volume mixer hydraulic pump is a good choice of pump or variable pump? Hydraulic pump station is the main component of concrete mixer, usually less than 6 mixers are the standard quantity pump, but it is recommended to choose variable pump, after the choice to clean every day, if there is no time can be cleaned once a week, that depends on the person.

普通攪拌車廠家的液壓系統是國產還是進口的？

一般廠家根據用戶需要選擇攪拌車尺寸和用戶需求，6方以下標配國產系統(可選擇進口),6方以上采用進口系統。
Is the hydraulic system of general mixer manufacturer made in China or imported? General Manufacturers in accordance with user needs to choose mixer size and user needs, 6 side below standard with domestic system (optional import) , more than 6 imported system.

新式攪拌車一般開幾年比較容易出問題？

拉物料一般為五年，濕料一般為七年，一般3方混凝土攪拌車在3年后容易出問題，攪拌車的問題和個人保養和生產廠家有很大的關系。

熟悉水泥自動攪拌車除機箱擋泥板以外的其他東西，包括攪拌罐體和支架，進出料斗，液壓系統和減速器，水箱和管道，操作連桿機構等。
How many years is it for a new type of truck to be in trouble? Pull material is usually five years, wet material is usually seven years, general 3 concrete mixer after 3 years easy problems, problems and personal maintenance and mixer manufacturers have a lot to do. Be Familiar with cement concrete mixer other than fenders, including mixing tanks and supports, in and out hoppers, hydraulic systems and reducers, water tanks and pipes, operating linkage mechanisms, etc. .

低于9方的攪拌車裝了大量混凝土，汽車爬坡時會漏水；12方攪拌車裝入混凝土后，攪拌會分層，混凝土砂率就偏低，石子粒徑偏小，路面會出現裂縫。

開動3方混凝土攪拌車，對有經驗的司機，一般安全駕駛常識都會懂。這里要提醒的是，由于混凝土是流動的，在車輛急轉彎時，一定要減慢車速，以免混凝土轉彎時產生離心力使車輛不穩！
A truck with less than 9 cubic meters of concrete is loaded with a lot of concrete, and water will leak when the truck climbs uphill. After 12 cubic meters of concrete are loaded into the truck, the concrete will be layered, the sand rate of the concrete will be low, the size of the gravel will be small, and cracks will appear on the road surface. Drive A three-way concrete mixer, for experienced drivers, General Safety driving knowledge will be understood. Here is to remind that, because the concrete is mobile, in the vehicle sharp turn, be sure to slow down the speed, so as not to produce centrifugal force when the concrete turning the vehicle unstable!

假如是由于混凝土原因，那就要看是因?yàn)樘涠忍∵€是混凝土強度太高，還是混凝土太粘下，以上原因可根據施工要求適當調整一下混凝土；如果總是不好，就要考慮葉片角度和下料口那塊有問題。
If it’s concrete, it depends on whether the slump is too small, the strength is too high, or the concrete is too sticky. The above reasons can be adjusted according to the construction requirements; if it’s always bad, you have to consider the blade angle and the cutting edge of the problem.

水泥固化后，混凝土的主要成分是硅酸二鈣、硅酸三鈣。從理論上講，鹽酸可以與之反應使其溶解。在實際操作過程中，由于攪拌車料口較小，鹽酸難以控制，而且鹽酸與攪拌車罐發生反應。實踐中，經常采用電焊或氣割等方法對罐體進行切割，凝固混凝土機械破碎。
After cement curing, the main components of concrete are dicalcium silicate and tricalcium silicate. In theory, hydrochloric acid can react with it to dissolve it. In the actual operation, because of the small material opening of the mixer, the hydrochloric acid is difficult to control, and the hydrochloric acid reacts with the mixer tank. In practice, the tank is often cut by electric welding or gas cutting, and the concrete is broken mechanically.

今天講述這些內容，希望能幫到駕駛水泥自動攪拌車的行家，攪拌車開多久還要看自己在日常的維護和了解它的部件等，這樣在接到新的攪拌機的時候知道怎么去保養以及維護它。
Today I want to tell you something that I hope will help the experts who drive the concrete mixer. How long the mixer will drive depends on my daily maintenance and understanding of its components, this way you know how to maintain and maintain a new mixer when you receive it.